變速箱滲油不厲害需要維修嗎？

來源：http://www.philiprobert.com發布時間：2021-02-01 17:56:24

變速箱漏油的主要原因，一個是管線破損，造成油在循環時，從管線破損處泄露。另一個就是變速箱與發動機連接處，密封墊損壞，或緊固螺栓松脫，導致連接縫擴大，密封效果變差，油從連接縫出滲漏。仔細檢查一下油是從什么地方滲漏的，如果是油封或端蓋上的O型橡膠密封圈損壞，更換。如果是制造工藝問題則要找廠家協商處理。
One of the main causes of transmission oil leakage is pipeline damage, which causes oil leakage from the damaged pipeline when circulating. The other is that the sealing gasket of the connection between the gearbox and the engine is damaged, or the fastening bolt is loose, which leads to the expansion of the joint, the poor sealing effect, and the leakage of oil from the joint. Carefully check where the oil is leaking from. If the oil seal or O-ring on the end cover is damaged, replace it. If it's a manufacturing process problem, consult with the manufacturer.
變速箱漏油維修費用要視故障情況來判斷，至少要2000元，嚴重的甚至要上萬元。變速箱的維修是整車修理中最為復雜的系統，為了避免出現漏油等故障情況，日常應做好定期更換變速箱油，變速箱油液位足夠。
The maintenance cost of transmission oil leakage depends on the fault situation, which should be at least 2000 yuan, and even tens of thousands of yuan in serious cases. Gearbox maintenance is the most complex system in vehicle repair. In order to avoid oil leakage and other faults, the gearbox oil should be replaced regularly, and the gearbox oil level is enough.
變速箱漏油，90%以上都是由密封件（油封）老化造成的！密封件（油封）時間長了會變硬，也就是說，隨著時間的推移他們失去增塑劑。這種過程因為持續的冷暖交替的工作溫度而加劇。這種糟糕過程的結果是，密封件首先開始收縮，接著變硬，最后甚至斷裂，漏油不可避免的出現。
Transmission oil leakage, more than 90% is caused by aging seal (oil seal)! Seals (oil seals) harden over time, that is, they lose plasticizer over time. This process is exacerbated by continuous alternating cold and warm working temperatures. As a result of this poor process, the seals begin to shrink first, then harden, and finally break, and oil leakage is inevitable.

變速箱漏油的解決方法：
Solutions to transmission oil leakage:
1、首先，用抹布或者紙巾擦干油跡，檢查漏油的部分，確定是那一邊漏的油，然后進行下一步的診斷。
1. First of all, wipe the oil stains with a cloth or paper towel, check the leaking part, determine which side is leaking oil, and then carry out the next diagnosis.
2、如果是鏈接螺樞松動，則把螺母擰緊即可。
2. If the link bolt is loose, tighten the nut.
3、若是襯墊破損，則需更換新的襯墊，通氣孔應該暢通，并且給變速箱里補充油份。
3. If the gasket is damaged, it needs to be replaced with a new gasket. The air vent should be unblocked and the oil in the gearbox should be replenished.
4、如果軸端部漏油，則可能要拆下變速器檢查，因為可能是波箱出現了問題。
4. If there is oil leakage at the end of the shaft, the transmission may have to be removed for inspection because there may be a problem with the gearbox.
5、如果是軸頸出現漏油，則應該把磨損的焊補修復或者更換部件。
5. If there is oil leakage in the journal, the worn parts should be repaired by welding or replaced.
以上就是濟南寶馬汽車維修http://www.philiprobert.com 感謝您在百忙之中查看我公司的信息內容，如果您想要了解的更多，歡迎您來電進行咨詢!
The above is Jinan BMW car maintenance http://www.philiprobert.comThank you for checking our company's information in your busy schedule. If you want to know more, you are welcome to inquire!